TATA BSVI Gasoline_Bifuel Program – EMS ECU Bosch DTC Troubleshooting Service Manual Version: 1.9 Date: 24-01-2022 Prepared By: Veer K. Singh / Prudhvi B Varma Checked By: Yeshwant Jadhav Approved By: Sanjeev M. Document Part No: 2921 02 xxx xxxx Page: 1539 of 1692 Copyright © TATA MOTORS Ltd. This document must not be used in any way, such as copying and redistributing to third parties, without the consent of author. P01A0-11: Electric min error for CNG tank pressure sensor - Tank pressure sensor short to Ground Overview: ISO Code P01A0-11 Customer Symptom CNG fuel gauge bar (1st bar and last bar) blinking Fault Effects (On Vehicle) CNG leak detection in the low pressure line is not activated. Lamp Status (If Any) MIL ON after 1 P0238 drive cycles Fault Detection Condition This fault occurs when tank pressure signal line Pin 109 short to Ground Normal Operating Condition Vehicle running in CNG Mode with normal operation Probable Trouble Area Wiring Harness Connections, CNG Tank Pressure Sensor, ECU Healing Condition After 3 drive cycles in CNG Fuel Mode Fault Permanent deletion 1. Clear DTC Command form Scan tool 2. Stack Over Flow. 3. 40 warm up cycles. 4. ECU Flashing. 5. ECU Power-Fail Component Details: The high-pressure sensor measures the fuel pressure in the CNG fuel tank and high-pressure line. This information is required by the engine control unit for the exact metering of the injected fuel mass. Preliminary Checks: 1) Sensor signal pin might be short circuit to ground. 2) Wiring harness problem 3) Wrong sensor fitted. 4) Faulty CNG tank pressure sensor. Trouble Shooting:- Step Checks IF YES IF NO 1. Check the continuity from sensor connector pins 2 to the ECU pins 109. Rectify/Replace Connectors Go to Step 2. 2. Sensor signal EMS ECU pin no.109 Short circuit to Ground Rectify/Replace Connectors Go to Step 3. 3. Check the continuity from sensor connector pins 2 to the ECU pins 109. Rectify/Replace Connectors Go to Step 4. 4. Fault Still Persists? Replace Sensor and then Fault still persists then Replace EMS ECU Follow the steps again for reconfirmation DTC’s confirmation:-
RkJQdWJsaXNoZXIy MTIwNTUz