431 / 5157
Nexon Gasoline – EMS ECU Bosch
DTC Troubleshooting Manual
Version: 0.1
Date: 26-08-2017
Prepared By: Sunu S Babu/Yogesh Jadhav
Checked By: Yeshwant Jadhav
Approved By: Satish Kumar
Document Part No: 2921 02 224 A1736
Page: 427 of 1203
Copyright ©
TATA MOTORS Ltd.
This document must not be used in any way, such as copying and redistributing to third parties, without the consent of author.
P0265-12: Injector 2 Short to Battery– Circuit Short to Battery
Overview:
ISO Code
P0265-12
Customer Symptom
Engine might Stall, Vehicle Acceleration poor, Idle not stable, Poor start
ability.
Fault Effects (On Vehicle)
Engine might Stall, Vehicle Acceleration poor, Idle not stable, Poor Start
ability, LAMBDA Control deactivated.
Lamp Status (If Any)
MIL ON after 1 drive cycle
Fault Detection Condition
This fault gets logged if the ignition state is ON and Injector of cylinder 2
control pin is short Circuited to battery.
Normal Operating Condition
Proper Wiring Harness connections between Injector of cylinder 2 and EMS
ecu.
Probable Trouble Area
Wiring Harness Connections
Healing Condition
Ignition ON and 3 driving Cycles
Fault permanent deletion
1. Clear DTC Command form Scan tool
2. Stack Over Flow.
3. 40 warm up cycles.
4.ECU flashing
5. ECU Power-Fail
Component Details:
Injectors are normally closed valve. Injector Opens when its electromagnetic coil is energized by the EMS ecu.
Preliminary Checks:
1) Loose/ Damaged Connections between injector and EMS ecu.
2) Check for back out of pins at both Injector connector and ECU connector.
3) Check for damage of pins at both injector connector and ECU connector.
4) Check the continuity from injector connector pins to the ECU pins.